|
 This Knowledgebase has been developed to cover the most frequently asked questions about Corvettes. Using our system, you can search for topics separated into categories by Corvette generation. Some of the information here comes directly from Chevrolet Service News publications, Service Bulletins, Recall Notices and other technical sources as indicated.
This Knowledgebase contains most service bulletins and recall notices for all model years. If you can't find a particular service bulletin here, try our Corvette Recall Notice & Service Bulletin Search Form which is linked to the National Highway Transportation Safety Administration. You will only be able to view a brief description of the bulletins from the NHTSA but must pay a fee to acquire the entire document.
DISCLAIMER:
This Knowledgebase contains information from other Corvette owners and enthusiasts as well as professional engineers, literature, and service technicians (where noted). Any information used from this Knowledgebase is used at your own risk. Although we do our best to screen and verify the information provided here, the Corvette Action Center is not responsible for any inaccuracy in this Knowlegebase. Always consult your service manual and/or a qualified automotive service technician before conducting automotive repairs. For further information, please review our Legal Disclaimer.
|
 Search the Knowledgebase |
 Browse by Category |
|
|
|
| View Articles by Category |
|
There are no sub categories
|
Engine - Drivetrain
|
|
|
(Page 1 of 2)
«« |
Prev |
1 |
2 |
Next |
»»
|
There were 23 articles found in this category:
 1997 - 1998: Service Bulletin: Belt Rumble Noise at Low Idle Speeds
Subject: BELT RUMBLE NOISE AT LOW IDLE SPEEDS (INSTALL ACCESSORY DRIVE BELT TENSIONER/ACCESSORY DRIVE BELT) Source: Chevrolet Dealer Technical Service Bulletin Number: 87-61-13 Models: 1997-1998 CHEVROLET CORVETTE WITH 5.7L ENGINE (VIN G - RPO LS1) AND 4L60-E AUTOMATIC TRANSMISSION BUILT PRIOR T ...
- 1997 - 1998: Service Bulletin: Reduced Engine Power Message Along With Partic. Powertrain
Subject: REDUCED ENG. POW. MESSAGE ALONG W/ PARTIC. PWRTRAIN Source: Chevrolet Dealer Technical Service Bulletin Number: 87-65-16 Models: 1997-98 CHEVROLET CORVETTE WITH 5.7L V8 ENGINE (VIN G - RPO LS1) Condition CONDITION #1: INTERMITTENT REDUCED ENGINE POWER EVENT, ACCOMPANIED BY P-1516, OR P1 ...
- 1997 - 1999: Service Bulletin: Accessory Drive Squeak (Replace Idler Pulley)
Subject: Technical - Accessory Drive Squeak (Replace Idler Pulley) Source: Chevrolet Service Bulletin Number: 99-06-01-007 Models: 1997 - 1999 Chevrolet Corvette 1998 - 1999 Chevrolet Camaro 1998 - 1999 Pontiac Firebird with 5.7 L Engine (VIN G - RPO LS1) Condition: Some customers may comment on ...
- 1997 - 1999: Service Bulletin: Engine Low Coolant Light Comes On (Inspect Rad. Surge Tank, Replace/Reposition)
Subject: Engine Low Coolant Light Comes On At Start-Up (Inspect for 2nd Design Radiator Surge Tank and Replace/Reposition) Source: Chevrolet Dealer Technical Service Bulletin Number: 99-06-02-016 Models: 1997-1999 Chevrolet Corvette (1997 Models Built Prior to VIN Breakpoint V5104277) This bulle ...
- 1997 - 2000: Service Bulletin: Intermittent Accessory Drive Rumble During Garage Shift
Subject: Intermittent Accessory Drive Rumble Noise During Garage Shift and/or During Parking Lot Maneuvers (Install New Generator with Decoupler Pulley and Accessory Drive Tensioner) Source: Chevrolet Dealer Technical Service Bulletin Number: 99-06-04-029A Models: 1997-2000 Chevrolet Corvette wi ...
- 1997 - 2002: Service Bulletin: SMU - Revised Side Cover and Gasket Replacement (RH)/Differential Carrier Cover and Seal Replacement
Source: Chevrolet Dealer Service Bulletin Number: 02-04-20-003 Date: 07-18-2002 Subject: SMU - Revised Side Cover and Gasket Replacement (RH)/Differential Carrier Cover and Seal Replacement - Right Model Year: 1997-2002 Chevrolet Corvette This bulletin is being issued to revise the Side Cover a ...
- 1997 - 2003: Service Manual Update: Revised Output Shaft Seal Replacement Procedure
Subject: Revised Output Shaft Seal Replacement Procedure Source: Chevrolet Dealer Technical Service Bulletin Number: 03-04-20-002 - (01/31/2003) Models: 1997-2003 Chevrolet Corvette This bulletin is being issued to revise the Output Shaft Seal Replacement procedure in the Rear Drive Axle sub-s ...
- 1997 - 2004: Service Bulletin: Fluid Leak at Rear Axle (Replace Left Differential Side Cover 0-Ring and Left Axle Shaft Seal, Add Sealant to Side Cover Flange)
Drivetrain - Rear Differential Fluid Leak Bulletin No.: 03-04-20-006 Date: November 18, 2003 TECHNICAL Subject: Fluid Leak at Rear Axle (Replace Left Differential Side Cover 0-Ring and Left Axle Shaft Seal, Add Sealant to Side Cover Flange) Models: 2004 Cadillac XLR 1997-2004 Chevrolet Corvett ...
- 1997 - 2004: Service Bulletin: Vehicle is Difficult to Fuel or Filling Station Pump Shuts Off Before Tank is Full
Service Bulletin #: 04-06-04-031 - Issued: 4/22/04 Vehicle is difficult to fuel or filling station pump shuts off before tank is full 1997 - 2004Chevrolet Corvette Condition: You may find that when attempting to fill your fuel tank with gas, the pump will shut down before the tank is actually ...
- 1998 - 2002: Service Bulletin: Audible Spark Knock (Detonation), MIL Illuminated, DTC P0332 Set
Subject: Audible Spark Knock (Detonation), MIL Illuminated, DTC P0332 Set (Replace Rear Bank Knock Sensor and RTV Area Around Sensor) Source: Chevrolet Dealer Technical Service Bulletin Number: 02-06-04-023 Models: 1998-2002 Chevrolet Camaro, Corvette, 1998-2002 Pontiac Firebird with 5.7L Engine ...
- 1998 - 2002: Service Bulletin: Needle Bearings Found In Oil Pan (Replace Rocker Arms)
Subject: Needle Bearings Found In Oil Pan (Replace Rocker Arms) Source: Chevrolet Dealer Technical Service Bulletin Number: 02-06-01-029 Models: 1998-2002 Chevrolet Camaro, Corvette 1998-2002 Pontiac Firebird 2002 Cadillac Escalade, Escalade EXT 1999-2002 Chevrolet Silverado 2000-2002 Chevrolet ...
- 1999 - 2002: Service Bulletin: Higher Than Expected Oil Consumption
Subject: Higher Than Expected Oil Consumption (Replace Rings and Engine Valley Cover) Source: Chevrolet Dealer Technical Service Bulletin Number: 01-06-01-023A Models: 1999-2001 Chevrolet Camaro, 1999-2002 Chevrolet Corvette, 1999-2001 Pontiac Firebird, with 5.7L Engine (VINs G, S -- RPOs LS1, L ...
- 2001 - 2002: Service Bulletin: SMU - Revised DTC P1221
Source: Chevrolet Dealer Service Bulletin Number: 02-06-04-005 Subject: SMU - Revised DTC P1221 Model Year: 2001-2002 Revised DTC P1221 2001-2002 Chevrolet Corvette 2001 Chevrolet and GMC C/K Pickup and Utility Models (Silverado, Sierra, Sierra C3, Suburban, Tahoe, Yukon, Yukon XL) 2001 Chevrole ...
- 2001 - 2003: Service Bulletin: Engine Knock or Lifter Noise
Subject: Engine Knock or Lifter Noise (Replace O-Ring) Model and Year: 2001-2002 Chevrolet Camaro 2001-2003 Chevrolet Corvette 2001-2002 Pontiac Firebird 2002-2003 Cadillac Escalade, Escalade EXT 2000-2003 Chevrolet Suburban, Tahoe 2001-2003 Chevrolet Silverado 2002-2003 Chevrolet Avalanche 200 ...
- 2001: Recall: Product Emission Recall Uncertified Calibration
2001 Corvette Recall GM Service Operations DCS890 Urgent - Distribute Immediately Date: February 14, 2001 Subject: 00103 - Product Emission Campaign Emission Label Error Models: MODELS: CERTAIN 2001 CHEVROLET CAMARO, CORVETTE; PONTIAC FIREBIRD EQUIPPED WITH 5.7L (RPO LS1 - VIN Code G; RPO LS6 - ...
- 2001: Service Bulletin: Lack of Power Following a Wide Open Throttle 4-2 or 3-2 Downshift and Subsequent 2-3 Upshift
Subject: Lack of Power Following a Wide Open Throttle 4-2 or 3-2 Downshift and Subsequent 2-3 Upshift (Reprogram PCM) Source: Chevrolet Dealer Technical Service Bulletin Number: 02-06-04-001 Date: January 2002 Models: 2001 Chevrolet Corvette with 5.7L Engine (VIN G – RPO LS1) Condition: ...
- 2001: Service Bulletin: Whistle Noise From Intake Manifold/Throttle Body (Replace Intake Manifold)
Subject: Whistle Noise From Intake Manifold/Throttle Body (Replace Intake Manifold) Source: Chevrolet Dealer Technical Service Bulletin Number: 02-06-01-021 Models: 2001 Chevrolet Corvette with 5.7L Engine (VINs G, S -- RPOs LS1, LS6) 1999-2002 Chevrolet and GMC C/K Pickup and Utility Models (Av ...
- 2003 - 2004: GM TechLink: Coolant Leak at Cup Plugs
From GM TechLink, June 2004: This information applies to 2003-04 Chevrolet and GMC C/K trucks, Cadillac Escalade, and Corvette, and 2004 Cadillac CTSV and Pontiac GTO with GEN III V8 engines. If coolant appears to be leaking at the head cup plugs, clean the area and inspect for an actual leak, ...
- 2003 - 2004: Service Information: Fuel Tank System
Corvette and Cadillac XLR Partway through model year 2003, a new fuel tank system was introduced on the Corvette (fig. 1). This system continues with slight differences in the 2004 Corvette and Cadillac XLR. TIP: For 2003 Corvettes only, this system was designated by RPO code FFS. However, thi ...
- 2004 - 2005: GM TechLink: Fuel Line Quick Connectors
From GM TechLink, February 2004: Two new style fuel line quick connects are in use. The TI Group Global Quick Connector is used on C/K trucks, S/T trucks, Malibu Sedan, Cadillac XLR and the 2004.5 and 2005 Chevrolet Corvette. The Legris QC is used on Aztek, Rendezvous, Venture, Montana and Silh ...
(Page 1 of 2)
«« |
Prev |
1 |
2 |
Next |
»»
|
|
