Supporting Vendors / Dealers - Advertising - Shop

2005 - 2006 Corvette: Recall: Painted Roof Adhesive Separation

NOTE:  The bulletin below was revised in June of 2006 to include the Z06 Corvette.  Below is bulletin #05112D in PDF format.

Custom Satisfaction Bulletin:
  #05112

Date: February 23, 2006

Subject:  Customer Satisfaction Program Painted Roof Adhesive Separation Service Procedure Revised

DESCRIPTION: CUSTOMER SATISFACTION PROGRAM #05112

On certain 2005-2006 Chevrolet Corvette vehicles, the painted roof panel may separate from its frame in some areas if it is exposed to stresses along with high temperature and humidity. The occupants of the vehicle may notice one or more of these symptoms: a snapping noise when driving over bumps, wind noise, poor roof panel fit, roof panel movement/bounce when a door or hatch is closed, or a water leak in the headliner.

Customer Satisfaction Program Bulletin 05112 was released on February 21, 2006 via GM Administrative Message WIR20060273.

Please be advised that Steps 3 and 23 in the service procedure have been revised. A copy of revised bulletin 05112A is attached below. Please discard all copies of bulletin 05112.

The Service Information System (SI) version of this bulletin will reflect this change in the near future.

Please review the revised procedure immediately and make sure that all affected service personnel are aware of this revision.

Click the attachment below for the bulletin and for the complete VIN list:

General Motors bulletins are intended for use by professional technicians, not a "do-it-yourselfer". They are written to inform those technicians of conditions that may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools, safety instructions and know-how to do a job properly and safely. If a condition is described, do not assume that the bulletin applies to your vehicle, or that your vehicle will have that condition. See a General Motors dealer servicing your brand of General Motors vehicle for information on whether your vehicle may benefit from the information.

© Copyright General Motors Corporation. All Rights Reserved

0 (0)
Article Rating (No Votes)
Rate this article
Attached Files (2)
Comments
There are no comments for this article. Be the first to post a comment.
Name
Email
Security Code Security Code
Related Articles RSS Feed
2005 Corvette: Service Bulletin: Information on the Operation of the Rear Compartment Lid/Hatch/Trunk Exterior Release Switch
Viewed 4159 times since Sun, Jul 20, 2014
2008 - 2009 Corvette: Campaign Recall: Convertible Roof Cover Separation
Viewed 983 times since Sun, Jul 6, 2014
2006 Corvette Z06: Service Bulletin: Information on Over-Filling Dry Sump Oiling System and Maintaining Proper Oil Level on LS7 Engine
Viewed 3556 times since Tue, Jul 15, 2014
2005 Corvette: Service Bulletin: Creak or Popping Noise from Roof Near Windshield/"A" Pillar (Replace Plastic Guides In Roof Striker)
Viewed 872 times since Sun, Jul 20, 2014
2005 - 2009 Corvette: Service Bulletin: Snap, Pop or Rattle Noise From Lift Off Roof Panel While Driving
Viewed 2252 times since Sun, Jul 6, 2014
2005 - 2012 Corvette: Service Bulletin: #PIC5558: Additional Diagnosis For Folding Top Temperature Messages Displayed On The DIC - (Oct 3, 2011)
Viewed 162 times since Fri, Mar 31, 2017
2005 - 2013 Corvettes - All Models: Grand Sport Stripe Kit Part Numbers
Viewed 1148 times since Thu, Mar 12, 2015
2005 - 2007 Corvette: Service Bulletin: Intermittent Spongy Clutch Pedal Sticking To The Floor During Hard Acceleration And High RPM Shifts
Viewed 5348 times since Sun, Jul 13, 2014
2006 Corvette Z06: GM Collison Repair and Complete Identification Manual
Viewed 642 times since Tue, Jul 15, 2014
2005 - 2007 Corvette: Service Bulletin: Rear Axle Clunk and/or Chatter Type Noise on Turns
Viewed 1296 times since Sun, Jul 13, 2014