Smog Pump makes rattling noise at idle, and when RPM's are dropping from reving motor
1985 C4 (110,000 easy miles) - Smog Pump makes rattling/vibration noise at idle, and when RPM's are dropping down to an idle. Seems fine while driving. When the A/C is on, it seems louder/worse at idle (or dropping to an idle). I thought it was an internal vibration in the Smog Pump, or bad bearings so I replaced it. Problem is, the new one is just as bad. Does anyone know what can be making this rattling/vibration noise in the Smog Pump.
Originally Posted by tigerdan
Are you 100% certain that it IS the smog pump? it could easily be the belt tensioner or water pump...even the altenator. If you use a section of 1/2" hose to listen to the pump and hold the end to your ear, you can clearly hear what is making noise.
Smog pumps do require some break-in time. Its very easy to ruin one by getting it wet or trying to lube it.
Once damaged it will eventually seize and leave you sitting there unable to drive.
The mfg says 500 miles to break a new pump in. They might continue to whine after that, but a rattle or squeeking is a sign that its damaged internally.
It is the pump making the vibration/noise
Thank you for the response... The noise is definitely from the Smog Pump area, and it is not a squeaking or purring noise typical of a normal pump if new. The tensioner was just replaced last week, the alternator is quiet, and the AC Compressor is not too old either. This is a new smog pump, but the noise/vibration is not a typical "new pump" noise. The noise is not there when the motor is above high idle (while driving), but when slowing down (about to stop) there is an intense vibration noise just before it drops to an idle. This is louder and vibrates more when the AC is on, but I think it is just the added strain on the belt drive system. With the hood open I can hear/feel the pump making this loud "brrrrr" vibration/noise. If I rev the motor it quiets down till I let off the throttle... when it drops almost to an idle and It will make the vibration/noise (and while it is idling).
Originally Posted by boomdriver
Question: Would anything with the Smog Pump air connection cause this problem? How is this checked out if so.
Any help would be greatly appreciated, I thought a tensioner pulley would have fixed it, then went for the bigger $$ item and replaced the Smog Pump - but nothing changed.
Are you sure that it's not just a worn diverter valve cycling as it should?? They have been known to make a lot of noise on decel.
Originally Posted by tigerdan
The only thing that you accomplish when you make something idiotproof, is breed a better grade of idiot,
I've also seen a PCValve that buzzed loudly at idle.
The A.I.R. system supposedly makes strange noises without the "muffler" that hangs on the side of the water pump. Thats there to allow air to escape the system and to keep the noise down. I have no idea what they sound like without the muffler.
There is an actual vibration on the smog pump/mount support bracket when the noise is present. I am wondering if one of the air valves being bad would cause a "pressure" problem in the pump resulting in this noise. I will check for a worn diverter valve, thank you for the idea. Do you have an easy way of checking the air valves in this area, other than just replacing a them? Again, thank you everyone for the help here, this rumbling vibration noise each time I stop or idle is embarrassing (and I am sure not good for the system).
By joshwilson3 in forum C4 Technical and Performance
Last Post: 06-20-10, 11:24 PM
By hoso in forum C3 Technical and Performance
Last Post: 08-20-09, 07:22 AM
By lwilliams in forum C6 General Discussion
Last Post: 01-02-05, 10:44 PM
By wwilkins in forum C3 General Discussion
Last Post: 08-23-04, 12:02 AM
By steve1ph in forum C4 Technical and Performance
Last Post: 10-02-03, 11:14 PM
Owned and Operated by © 2000-2015 Corvette Action Center | |
© CORVETTE is a registered trademark of the General Motors Corporation & Chevrolet Motor Division. Neither Chevrolet Motor Division nor any subsidiaries of GM© shall bear any responsibility for CorvetteActionCenter.com content, comments, or advertising. CorvetteActionCenter.com is independent from GM© and is not affiliated with, sponsored or supported by GM©. Copyright/trademark/sales mark infringements are not intended, or implied. All Rights Reserved